| 刘 凯,赵光磊,何北海,陈礼辉,黄六莲.造纸白水中金属离子对浆料Zeta电位的影响[J].中国造纸学报,2012,27(3):25-28 |
二维码（扫一下试试看！） |
| 造纸白水中金属离子对浆料Zeta电位的影响 |
| Effect of Metal Ions in Whitewater of Papermaking on the Zeta Potential of the Pulp |
| |
| DOI： |
| 中文关键词: 造纸白水 金属离子 留着率 Zeta电位 |
| Key Words:whitewater metal ion retention Zeta potential |
| 基金项目: |
| 作者 | 单位 | | 刘 凯1 | 1.福建农林大学材料工程学院, 福建福州, 350002 | | 赵光磊2 | 2.华南理工大学制浆造纸工程国家重点实验室, 广东广州, 510640 | | 何北海2 | 2.华南理工大学制浆造纸工程国家重点实验室, 广东广州, 510640 | | 陈礼辉1 | 1.福建农林大学材料工程学院, 福建福州, 350002 | | 黄六莲1 | 1.福建农林大学材料工程学院, 福建福州, 350002 |
|
| 摘要点击次数: 3782 |
| 全文下载次数: 1189 |
| 中文摘要: |
| 利用原子吸收光谱法测定文化用纸纸机网下白水中金属离子含量，考察金属离子含量对浆料与填料留着率以及浆料Zeta电位的影响。研究结果表明，白水中积累的3种主要金属离子分别为Fe3+、Mn2+和Ca2+，其含量分别为0.088、0.035和87.2 mg/L；白水中积累的金属离子有助于提高浆料与填料的留着率；白水中低含量的Fe3+和Mn2+对浆料Zeta电位的影响较小，而高含量的Ca2+对浆料Zeta电位的影响很大；随Ca2+含量的增加，浆料Zeta电位急剧升高；在Ca2+一定量的条件下，随阳离子聚丙烯酰胺（CPAM）用量的增加，浆料Zeta电位也会升高，从而增强了CPAM对浆料与填料的絮凝作用。 |
| Abstract: |
| The metal ion contents in the whitewater under the wire section of paper machine were determinated by the atomic absorption spectrometry,and the effects of the contents of Fe3+， Mn2+， Ca2+ in whitewater on the retention of the pulp and filler and the Zeta potential of pulp were also investigated. The results showed that the three metal ions accumulating in the whitewater were Fe3+, Mn2+ and Ca2+, and their contents were 0.088, 0.035 and 87.2 mg/L, respectively. Moreover, the metal ions were proved to be of benefit to increase the retention of the pulp and filler. The Zeta potential of the pulp was less affected by Fe3+ and Mn2+, but was affected by high content of Ca2+ significantly. The Zeta potential of the pulp increased rapidly with the increase of the concentration of Ca2+. The Zeta potential of the pulp also increased with the concentration of CPAM increasing when Ca2+ was in centain level. It would enhance the flocculation of the pulp and filler causing by CPAM. |
| 查看全文 查看/发表评论 下载PDF阅读器 HTML |
|
|
|
