| 张春辉,付时雨,刘 玉,张凤山,詹怀宇.阔叶木与非木材纤维原料混合制浆的研究[J].中国造纸学报,2015,30(2):18-21 |
二维码（扫一下试试看！） |
| 阔叶木与非木材纤维原料混合制浆的研究 |
| Study on the Mixture Pulping of Hardwood and Non-wood Materials |
| |
| DOI：10.11981/j.issn.1000-6842.2015.02.18 |
| 中文关键词: 非木材 阔叶木 硫酸盐法制浆 无元素氯漂白 |
| Key Words:non-wood hardwood kraft pulping elemental chlorine free bleaching |
| 基金项目:国家自然科学基金(No.21406079)；中央高校基本科研业务经费项目(No.2014ZM0065)；制浆造纸科学与技术教育部实验室基金(No.KF2012001)；山东省博士后创新基金项目(No.201302008)。 |
| 作者 | 单位 | | 张春辉1,2,3,* | 1.华南理工大学制浆造纸工程国家重点实验室,广东广州,510640；2.齐鲁工业大学制浆造纸科学与技术教育部重点实验室,山东济南, 250353； 3.华泰集团有限公司,山东东营, 257335 | | 付时雨1 | 1.华南理工大学制浆造纸工程国家重点实验室,广东广州,510640 | | 刘 玉2 | 2.齐鲁工业大学制浆造纸科学与技术教育部重点实验室,山东济南, 250353 | | 张凤山3 | 3.华泰集团有限公司,山东东营, 257335 | | 詹怀宇1 | 1.华南理工大学制浆造纸工程国家重点实验室,广东广州,510640 |
|
| 摘要点击次数: 4202 |
| 全文下载次数: 1318 |
| 中文摘要: |
| 对阔叶木(杂交杨木)与非木材纤维原料(芒草、柳枝稷、玉米秸秆)的混合硫酸盐法制浆和ECF(无元素氯)漂白(漂序为OD(EP)D)进行了探讨。结果表明,在杨木木片中加入一定比例的上述非木材纤维原料(10%～30%)时,纸浆抗张强度有所提高,提高幅度在20%～25%之间。通过对纸浆碳水化合物组分进行分析发现,纸浆强度的提高与其聚木糖含量有关,即将少量聚木糖含量较高的非木材纤维原料与阔叶木一起混合蒸煮,能够获得品质优良的纸浆。 |
| Abstract: |
| The pulping of the mixture of non-wood materials and hardwoods was investigated in the paper.Three non-wood materials,miscanthus,switchgrass and corn stover were partially substituted for poplar wood chips and the mixture was subjected to typical kraft pulping experiments.The pulp was then bleached with an OD(EP)D sequence.The bleached pulp was refined and formed into handsheets to characterize their physical properties.The results showed that all pulps produced from the mixture raw materials had improved strength properties compared with the poplar pulp.Carbohydrate analysis of the pulps indicated that the strength increase was correlated with enriched xylan content in the pulp.Based on these results,cooking of hardwood mixing certain amount of non-wood materials contained high xylan content could produce high quality pulp. |
| 查看全文 查看/发表评论 下载PDF阅读器 HTML |
|
|
|
